Synthesis of two supramolecular coordination polymers and electrochemical evaluation of their corrosion inhibition performance on corrosion of carbon steel in acidic medium

Waseef Essam El; Safaa Eldin H. Etaiw

doi:10.5937/zasmat2104316F

Authors

Waseef Essam El Mansoura University, Faculty of Science, Department of Chemistry, Mansoura, Egypt Author
Safaa Eldin H. Etaiw Tanta University, Faculty of Science, Department of Chemistry, Tanta, Egypt Author

DOI:

https://doi.org/10.5937/zasmat2104316F

Keywords:

Supramolecular coordination polymers, acid corrosion, carbon steel, Henry isotherm, EIS

Abstract

The effect of the SCPs-[CuII(en)2] [CuI (CN)2]2. H2O] (SCP1) and {[H2DAB] [Cu4(CN)6].2H2O} (SCP2) as corrosion inhibitors for carbon steel (CS) was studied in 1.0M HCl solution. As the synthesized inhibitor dose increases, the inhibition productivity (%e) increases reaching to 90.3% and 89.9% at 21x10-6M dose for SCP2 and SCP1, respectively. This result evidenced by mass loss (ML) investigated at three different temperatures 25-35-45oC, while potentiodynamic polarization (PP), electrochemical impedance spectroscopy (EIS), and electrochemical frequency modulation technique (EFM) were tested at 25°C. The synthesized inhibitors adsorbed on the CS surface physically allowing Henry isotherm. The results displayed that the synthesized inhibitors are excellent and their (%e) was significantly increased by raising the dose and decreased by raising the temperature. Polarization curves revealed that the synthesized inhibitors act as mixed type. The thermodynamic parameters were calculated and discussed. The protection was confirmed by the creation of the thin film of inhibitors precipitated on the surface of CS.

References

Abd, E.F.S., Ali, A.H. (2018) Egy-dronate drug as promising corrosion inhibitor of C-steel in aqueous medium.Zaštita materijala, vol. 59, br. 1, str. 126-140

https://doi.org/10.5937/ZasMat1801128F

Abd-el-naby, B.A., Abdullatef, O.A., Khamis, E., el-Mahmody W.A. (2016) Effect of cetyltrimethyl ammonium bromide surfactant as novel inhibitor for the corrosion of steel in 0.5 M H2SO4.Int. J. Electrochem. Sci, 11, 1271-1281

https://doi.org/10.1016/S1452-3981(23)15920-7

Al-Sabbagh, A.M., Osman, M.M., Omar, A.M.A., El-Gamal, I.M. (1996) Organic corrosion inhibitors for steel pipelines in oilfields.Anti-Corrosion Methods and Materials, 43(6), 11-16

https://doi.org/10.1108/eb007405

Amin, M.A., Abd, E.S.S., El-Naggar, M.M., Abd, E.H.T. (2009) Adsorption, and corrosion inhibitive properties of some tripodal pyrazolic compounds on mild steel in hydrochloric acid systems.J Mater. Sci, 44, 6258-6272

https://doi.org/10.1007/s10853-009-3856-2

Bosch, R.W., Hubrecht, J., Bogaerts, W.F., Syrett, B.C. (2001) A new electrochemical technique for online corrosion monitoring.Corrosion, 57, 60-70

https://doi.org/10.5006/1.3290331

di Y., Zongxue, Y., Legang, C., Kunyao, C. (2019) Enhancement of the anti-corrosion performance of composite epoxy coatings in presence of bta loaded copper-based metal-organic frameworks.Int. J. Electrochem. Sci, 14, 4240-4253

https://doi.org/10.20964/2019.05.13

Eddy, N.O., Ebenso, E.E. (2010) Adsorption and quantum chemical studies on cloxacillin and halides for the corrosion of mild steel in acidic media.Int. J. Electrochem. Sci, 5, 731-750

https://doi.org/10.1016/S1452-3981(23)15319-3

Elabbasy, H.M., Zidan, S.M., El-Aziz, A.F.S. (2019) Inhibitive behavior of Ambrosia Maritima extract as an eco-friendly corrosion inhibitor for carbon steel in 1M HCI.Zaštita materijala, vol. 60, br. 2, str. 129-146

https://doi.org/10.5937/zasmat1902129E

Etaiw, S.el-Din H.E.H., Fouda, A.el-Aziz S.S., Amer, S.A., el-Bendary Mohamed, M. (2011) Structure, characterization and anti-corrosion activity of the new metal-organic framework [Ag(qox)(4-ab)].Journal of Inorganic and Organometallic Polymers and Materials, 21(2), 327-335

https://doi.org/10.1007/s10904-011-9467-9

Etaiw, S.el-Din H.E.H., Badr, el-Din A.S. (2011) Supramolecular design of coordination polymers based on silver(I) azide and nitrogen donor ligands.Journal of Inorganic and Organometallic Polymers and Materials, 21(1), 1-8

https://doi.org/10.1007/s10904-010-9427-9

Etaiw, S.H.E.H., Abdou, S.N., Badr, el-Din A.S. (2015) Structure and spectral characterization of coordination polymers constructed by Cu CN and aliphatic diamines.Journal of Inorganic and Organometallic Polymers and Materials, 25(6), 1394-1406

https://doi.org/10.1007/s10904-015-0252-z

Fouda, A.S., Abdallah, M., el-Badrawy Z. (2011) Some hydrazone derivatives as corrosion inhibitors for iron in 3.5% H3PO4 solution.Afri. J. Pure Appl. Chem, 5(8), 24-36

Fouda, A.S., Abdel, A.M., Mohamed, S.A., El-Hossiany, A., El-Desouky, E. (2019) Corrosion inhibition and adsorption behavior of nerium oleander extract on carbon steel in hydrochloric acid solution.Int. J. Electrochem. Sci, 14, 3932-3948

https://doi.org/10.20964/2019.04.44

Fouda, A.S., Mostafa, H.A., Elewady, G.Y., El-Hashemy, M.A. (2008) Low molecular weight straight - chain diamines as corrosion inhibitors for ss in HCl solution.Chemical Engineering Communications, 195(8), 934-947

https://doi.org/10.1080/00986440801905148

Fouda, A.S., Abd, E.S.A., El-Hossiany, A., Ibrahim, A. (2019) Corrosion protection of stainless steel 201 in acidic media using novel hydrazine derivatives as corrosion inhibitors.Int. J. Electrochem. Sci, 14, 2187-2207

https://doi.org/10.20964/2019.03.15

Fouda, A.S., Shalabi, K., el-Hossiany A. (2016) Moxifloxacin antibiotic as green corrosion inhibitor for carbon steel in 1 M HCl.Journal of Bioand Tribo-Corrosion, 2(3), 18-26

https://doi.org/10.1007/s40735-016-0048-x

Fouda, A.S., Ibrahim, H., Rashwan, S., El-Hossiany, A., Ahmed, R.M. (2018) Expired drug (pantoprazole sodium) as a corrosion inhibitor for high carbon steel in hydrochloric acid solution.Int. J. Electrochem. Sci, 13, 6327-6346

https://doi.org/10.20964/2018.07.33

Fouda, A.E.S.S., Etaiw, S.E.H.E.H., El-Bendary, M.M., Maher, M.M. (2016) Metal-organic frameworks based on silver (I) and nitrogen donors as new corrosion inhibitors for copper in HCl solution.Journal of Molecular Liquids, 213, 228-234

https://doi.org/10.1016/j.molliq.2015.11.001

Fouda, E.A.S., El-Hossiany, A.A., Ramadan, H.M. (2017) Calotropis Procera plant extract as green corrosion inhibitor for 304 stainless steel in hydrochloric acid solution.Zaštita materijala, vol. 58, br. 4, str. 541-555

https://doi.org/10.5937/ZasMat1704541F

Fouda, E.A.S., El-Khateeb, A.Y., Elbahrawi, N.M. (2017) Cupressus sempervirens extract as green inhibitor for corrosion of carbon steel in hydrochloric acid solutions.Zaštita materijala, vol. 58, br. 2, str. 131-143

https://doi.org/10.5937/ZasMat1702131F

Fouda, E.A.S., El-Maksoud, A.S.A., el-Salam Abd, S.A. (2017) Mitigation of corrosion of carbon steel in acid medium using some antipyrine derivatives.Zaštita materijala, vol. 58, br. 1, str. 5-17

https://doi.org/10.5937/ZasMat1701005F

Frignani, A., Grassi, V., Zanotto, F., Zucchi, F. (2012) Inhibition of AZ31 Mg alloy corrosion by anionic surfactants.Corrosion Science, 63, 29-39

https://doi.org/10.1016/j.corsci.2012.05.012

Garcia-Arriaga, V., Alvarez-Ramirez, J., Amaya, M., Sosa, E. (2010) H2S and O2 influence on the corrosion of carbon steel immersed in a solution containing 3 M diethanolamine.Corrosion Science, 52(7), 2268-2279

https://doi.org/10.1016/j.corsci.2010.03.016

Grgur, B.N. (2020) Corrosion of the stainless steel 316Ti in 10% hydrochloric and sulfuric acid.Zaštita materijala, vol. 61, br. 4, str. 339-345

https://doi.org/10.5937/zasmat2004339G

Jayaperumal, D. (2010) Effects of alcohol-based inhibitors on corrosion of mild steel in hydrochloric acid.Materials Chemistry and Physics, 119(3), 478-484

https://doi.org/10.1016/j.matchemphys.2009.09.028

Jones, D.A. (1983) Principles and prevention of corrosion. Upper Saddle River, NJ: Prentice Hall, second ed

Kendig, M., Jeanjaquet, S. (2002) Cr(VI) and Ce(III) inhibition of oxygen reduction on copper.Journal of The Electrochemical Society, 149(2), B47-B51

https://doi.org/10.1149/1.1430717

Khaled, K.F. (2009) Evaluation of electrochemical frequency modulation as a new technique for monitoring corrosion and corrosion inhibition of carbon steel in perchloric acid using hydrazine carbodithioic acid derivatives.Journal of Applied Electrochemistry, 39(3), 429-438

https://doi.org/10.1007/s10800-008-9688-y

Khaled, K.F. (2008) Molecular simulation, quantum chemical calculations and electrochemical studies for inhibition of mild steel by triazoles.Electrochimica Acta, 53(9), 3484-3492

https://doi.org/10.1016/j.electacta.2007.12.030

Khaled, K.F. (2008) New synthesized guanidine derivative as a green corrosion inhibitor for mild steel.Int. J. Electrochem. Sci, 3, 462-475

https://doi.org/10.1016/S1452-3981(23)15466-6

Khamis, E., Bellucci, F., Latanision, R.M., El-Ashry, E.S.H. (1991) Acid corrosion inhibition of nickel by 2-(Triphenosphoranylidene) succinic anhydride.Corrosion, 47(9), 677-686

https://doi.org/10.5006/1.3585307

Kowsari, E., Payami, M., Amini, R., Ramezanzadeh, B., Javanbakht, M. (2014) Task-specific ionic liquid as a new green inhibitor of mild steel corrosion.Applied Surface Science, 289, 478-486

https://doi.org/10.1016/j.apsusc.2013.11.017

Kruger, J. (1986) Corrosion of metal: An overview. in: Bever M.B. [ed.] Encyclopedia of materials science and engineering, vol 2

Kumaraguru, S., Pavulraj, R., Mohan, S. (2017) Influence of Co, Ni, Cu-based MOFs on the corrosion protection of mild steel.Int. J. Surf. Eng. Coat, 95(3), 131-136

https://doi.org/10.1080/00202967.2017.1283898

Li, X.H., Deng, S.D., Fu, H. (2009) Synergistic inhibition effect of red tetrazolium and uracil on the corrosion of cold rolled steel in H3PO4 solution: Weight loss, electrochemical, and AFM approaches.Materials Chemistry and Physics, 115(2-3), 815-824

https://doi.org/10.1016/j.matchemphys.2009.02.025

Malinović, B., Đuričić, T., Zorić, D. (2020) Corrosion behaviour of stainless steel EN 1.4301 in acid media in presence of PBTCA inhibitor.Zaštita materijala, vol. 61, br. 2, str. 133-139

https://doi.org/10.5937/zasmat2002133M

Martinez, S., Metikoš-Huković, M. (2003) A nonlinear kinetic model introduced for the corrosion inhibitive properties of some organic inhibitors.Journal of Applied Electrochemistry, 33(12), 1137-1142

https://doi.org/10.1023/B:JACH.0000003851.82985.5e

McCafferty, E., Hackerman, N. (1972) Double layer capacitance of iron and corrosion inhibition with polymethylene diamines.Journal of The Electrochemical Society, 119(2), 146-154

https://doi.org/10.1149/1.2404150

Migahed, M.A., Abd-El-raouf, M., Al-Sabagh, A.M., Abd-El-bary, H.M. (2005) Effectiveness of some non ionic surfactants as corrosion inhibitors for carbon steel pipelines in oil fields.Electrochimica Acta, 50(24), 4683-4689

https://doi.org/10.1016/j.electacta.2005.02.021

Mooibroek, T.J., Aromí, G., Quesada, M., Roubeau, O., Gamez, P., Debeer, G.S., van Slageren, J., Yasin, S.V., Ruiz, E., Reedijk, J. (2009) A mixed-valent pentanuclear CuII4Cui compound containing a radical-anion ligand.Inorganic Chemistry, 48(22), 10643-10651

https://doi.org/10.1021/ic901337r

Nakomčić, J., Vaštag, Đ. (2016) Derivati tiazola i triazol kao inhibitori korozije metala - I deo.Zaštita materijala, vol. 57, br. 2, str. 183-195

https://doi.org/10.5937/ZasMat1602183N

Nicho, M.E., Hu, H., Gonzalez-Rodriguez, J.G., Salinas, V.M. (2006) Protection of stainless steel by polyaniline films against corrosion in aqueous environments.J Appl. Electrochem, 36(2), 153-160

https://doi.org/10.1007/s10800-005-9040-8

Paul, S.D., George, G.A., Nanayakkara, A.K., Steinert, D.A. (1988) The protective action of epoxy resins and curing agents-inhibitive effects on the aqueous acid corrosion of iron and steel.Corrosion Science, 28(1), 33-42

https://doi.org/10.1016/0010-938X(88)90004-2

Rajendran, S., Agasta, M., Devi, B.R., Devi, S.B., Rajam, K., Jeyasundari, J. (2009) Corrosion inhibition by an aqueous extract of Henna leaves (Lawsonia Inermis L).Zaštita materijala, vol. 50, br. 2, str. 77-84

Sakinch, Z., Mahdi, N.S., Mahboube, G. (2020) New MOF based corrosion inhibitor for carbon steel in acidic media.Met. Mater. Int., 26, 25-38

https://doi.org/10.1007/s12540-019-00307-1

Saliyan, V.R., Adhikari, A.V. (2008) Inhibition of corrosion of mild steel in acid media by N'-benzylidene-3-(quinolin-4-ylthio) propanohydrazide.Bull. Mater. Sci, 31, 699-711

https://doi.org/10.1007/s12034-008-0111-4

Sasikumar, Y., Adekunle, A.S., Olasunkanmi, L.O. (2015) Experimental, quantum chemical and Monte Carlo simulation studies on the corrosion inhibition of some alkyl imidazolium ionic liquids containing tetrafluoroborate anion on mild steel in acidic medium.Journal of Molecular Liquids, 211, 105-118

https://doi.org/10.1016/j.molliq.2015.06.052

Schweinsberg, D.P., Ashworth, V. (1988) The inhibition of the corrosion of pure iron in 0.5 M sulphuric acid by n-alkyl quaternary ammonium iodides.Corrosion Science, 28(6), 539-548

https://doi.org/10.1016/0010-938X(88)90022-4

Shalaby, M.N., Osman, M.M. (2009) Protection of copper surface against corrosion by cationic surfactant in seawater.Journal of Dispersion Science and Technology, 30(5), 677-683

https://doi.org/10.1080/01932690802598986

Shin, H., Mansfeld, H. (1989) A fitting procedure for impedance data of systems with very low corrosion rates.Corros.Sci, 29, 1235-1240

https://doi.org/10.1016/0010-938X(89)90070-X

Sokolova, P.E., Raicheva, S., Christov, M. (2003) AC and DC study of the temperature effect on mil A.d steel corrosion in acid media in the presence of benzimidazole derivatives.Corros. Sci, 45, 33-58

https://doi.org/10.1016/S0010-938X(02)00072-0

Stocker, F.B., Britton, D., Young, V.G. (2000) Crystal structures of a family of silver cyanide complexes of thiourea and substituted thioureas.Inorganic Chemistry, 39(16), 3479-3484

https://doi.org/10.1021/ic990859l

Tammam, R.H., Fekry, A.M., Saleh, M.M. (2016) Understanding different inhibition actions of surfactants for mild steel corrosion in acid solution.J Electrochem. Sci, 11, 1310-1326

https://doi.org/10.1016/S1452-3981(23)15923-2

Williams, R.J., Larson, A.C., Cromer, D.T. (1972) The crystal structure of the mixed valence copper cyanide ethylenediamine complex: aquobis(en)copper(II) di-[catena-di-m-cyanocuprate(I)], Cu3(en)2(CN)4.H2O.Acta Crystallographica Section B Structural Crystallography and Crystal Chemistry, 28(3), 858-864

https://doi.org/10.1107/S0567740872003310

*** (2003) Gamry Echem analyst manual